Product ID:M8-099, MIL-C-22750E GRAY 36320, COMP A
MSDS Date:12/02/1993
FSC:8010
NIIN:01-316-3035
Kit Part:Y
MSDS Number: BVBPV

CRAWFORD LABS, INC

4165 S EMERALD AVE
CHICAGO, IL 60609
US

Emergency Phone: 312-433-1307

Info Phone: 312-376-7132

Preparer: DAVID SCHMETTERER

Cage: 5V430

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 71.2 MM HG)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 13%

OSHA PEL 100 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

100 SOLVENT (VAPOR PRESSURE 9 MM HG)

CAS: 64742-95-6

Fraction By Weight: 1.6%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

TOLUENE (SARA III) (VAPOR PRESSURE 38 MM HG)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 3.0%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM;STEL 150 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

REACTION PRODUCTS OF EPICHLOROHYDRIN & BISPHENOL A

CAS: 25085-99-8

Fraction By Weight: 19%

DILUENT 8

CAS: 68609-97-2

Fraction By Weight: 2.0%

TITANIUM OXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 17%

ACGIH TLV: 10 MG/M3

AMORPHOUS SILICA (0-10% OF TITANIUM OXIDE)

CAS: 112926-00-8

RTECS: VV8850000

ALUMINIUM HYDROXIDE (0-9% OF TITANIUM OXIDE)

CAS: 21645-51-2

RTECS: BD0940000

DIATOMACEOUS EARTH

CAS: 68855-54-9

Fraction By Weight: 14%

Health Hazards Acute and Chronic:OVEREXPOSURE MAY PRODUCE VARIOIUS
EFFECTS, INCLUDING: ACUTE TOXICITY, RESULTING IN HEADACHE,
DIZZINESS, NAUSEA, & LOSS OF CONSCIOUSNESS. SEVERE EYE IRRITATION
POSSIBLY RESULTING IN PERMANENT DAMAGE. I RRITATED MUCOUS
MEMBRANES. VOMITING DUETO INGESTION. DEFATTING & DRYING OF SKIN.
SENSITIZATION AFTER REPEATED CONTACT.
Effects of Overexposure:REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE C ONTENTS MAY BE HARMFUL OR FATAL.

First Aid:EYE: FLUSH W/LUKEWARM LOW PRESSR WATER 15 MIN, LIFTING
EYELIDS. GET MED AID. INHAL: REMOVE TO FRESH AIR. GIVE OXYGEN IF
BREATHING DIFFICULT. GIVE ARTIF RESP IF NO BREATH. GET MED AID.
KEEP WARM & COMF ORTABLE. NOTHING BY MOUTH TO UNCONSCIOUS PERSON.
INGESTION: CALL DR IMMED. ONLY INDUCE VOMITING ON DR'S
INSTRUCTIONS. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS. NOTHING BY
MOUTH TO UNCONSCIOUS PERSON.*

Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:0.9
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP EXPOSED CONTAINER
COOL, & KEEP FLAMMABLE STRUCTURES WET. DON'T ENTER FIRE AREA W/O
PROTECTION BECAUSE HAZARDOUS DECOMP MAY BE PRESENT.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.

Spill Release Procedures:WARNING--FLAMMABLE. ELIMINATE IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITH AN ABSORBENT AND PLACE IN NON-LEAKING CONTAINERS. SEAL
TIGHTLY FOR PROPER DISPOSAL .

Handling and Storage Precautions:FLAMMABLE.KNOW DOT REGS BEFORE
TRANSPORT.HOT ORGANIC CHEM VAPORS SUSCEPTIBLE TO SUDDEN SPONTANEOUS
COMBUSTION WHEN MIXED W/AIR.IGNITION MAY OCCUR AT**
Other Precautions:**TEMP BELOW AUTOIGNIT TEMP.IGNIT TEMP DECREASE
W/INCREASING VAPOR VOLUME & VAPOR/AIR CONTACT TIME & PRESSR
CHANGE.HOT VAPOR MAY IGNITE W/AIR BELOW AUTOIGNITN.IGNITN MAY OCCUR
AT HIGH TEMP W/SUDDEN IN GRESS OR ESCAPE OF VAPORS TO ATMOSPHERE.

Respiratory Protection:IMPORTANT - MUST PROVIDE ADEQUATE VENTILATION TO
MAINTAIN VAPOR CONCENTRATIONS BELOW ESTABLISHED TLV LIMIT AS GIVEN
BY OSHA. IN MORE CONFINED AREA NIOSH-MSHA APPROVED RESPIRATOR
EQUIPPED WITH ORGANIC VAPOR CARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADQUATE VENTILATION, SEE RESPIRATORY
PROTECTION.
Protective Gloves:USE RUBBER GLOVES
Eye Protection:WEAR SAFETY GOGGLES AND/OR FACE SHIELD
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
* FIRST AID CONT'D: SKIN: FLUSH WITH WATER WHILE REMOVING CONTAMINATED
CLOTHING AND SHOES. FOLLOW BY WASHING WITH SOAP AND WATER. DO NOT
REUSE CONTAMINATED CLOTHING & SHOES. IF IRRITATION PERSISTS, GE T
MEDICAL ATTENTION.

HCC:F3
Boiling Pt:B.P. Text:174 TO 344F
Vapor Density:> AIR
Spec Gravity:1.53
Viscosity:64 KU
Evaporation Rate & Reference:3.69 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:GRAY LIQUID / SOLVENT ODOR
Percent Volatiles by Volume:34.2
Corrosion Rate:NOT CORR

Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES, AND
INCOMPATIBILITIES.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE & OTHER
TOXIC GASES.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURENT
LOCAL, STATE AND FEDERAL REGULATIONS. CONTACT AN APPROVED DISPOSAL
FACILITY. EPA HAZARDOUS WASTE CODES: D001. HAZARDOUS WASTE
CHARACTERISTICS: IGNITABLE. DIS POSAL METHODS: FUEL CONSUMPTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.